UPC 024185789833

Volvo Penta Stern Drives 2001-2004Part #: B775688 pagesQUICK REFERENCE DATACHAPTER ONE / GENERAL INFORMATIONCHAPTER TWO / TROUBLESHOOTINGCHAPTER THREE / LUBRICATION MAINTENANCE AND TUNE-UPCHAPTER FOUR / LAY-UP WINTERIZING AND FITTING OUTCHAPTER FIVE / ADJUSTMENTSCarburetor / Ignition timing / Shift cable and linkage / Throttle cable / Trim position sender and trim limit control module / SpecificationsCHAPTER SIX / ENGINERemoval installation / Engine alignment / Rocker arm cover / Valve adjustment / Placing the No. 1 piston at TDC / Lifter cover / Camshaft lobe lift measurement / Cylinder head / Rocker arm and pushrod / Flywheel housing / Drive coupler / Drive plate / Flywheel / Flywheel pilot bearing / Output drive shaft seals and bearings / Oil pan pump / Harmonic balancer / Timing gear/chain cover / Timing chain and sprockets / Balance shaft / Camshaft and lifters / Piston and connecting rod / Rear main seal and rear main seal carrier / Crankshaft / Break-in procedure / SpecificationsCHAPTER SEVEN / FUEL SYSTEMSFuel system service / Mechanical fuel pump / Low-pressure electric fuel pump / Carburetor / Electronic fuel injection (EFI) / Intake manifold / SpecificationsCHAPTER EIGHT / COOLING AND EXHAUST SYSTEMSThermostat / Recirculation pump / Seawater pump / Oil and power steering fluid cooler / Exhaust elbow / Exhaust bellow and flapper valve / Exhaust tube and flapper valve / Exhaust manifold / SpecificationsCHAPTER NINE / ELECTRICAL SYSTEMBattery / Alternator / Starter motor and solenoid / Starter relay / Fuel pump relay / EFI system relay / Ignition system / Oil pressure sender / Oil pressure switch / Engine temperature sender / Engine temperature sensor / Engine overheat switch / Exhaust overheat switch / Intake air temperature sensor IAT / Throttle position sensor TPS / Idle air control motor IAC / Knock sensor / Knock sensor module / Engine control unit ECU / Warning horn replacement / SpecificationsCHAPTER TEN / DRIVE UNITDrive unit service precautions